攪拌車的驅動裝置也是需要維護的_自動混凝土攪拌車_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌車

熱點

自動上料攪拌車的使用方法

2022-01-10

自動攪拌車的變速器油面和油質如何檢測?

2021-06-10

混凝土攪拌車制動踏板故障原因？

2021-05-10

山汽集團告訴你怎么提高攪拌車的效率

2021-11-27

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

攪拌車的驅動裝置也是需要維護的

所屬分類：自動混凝土攪拌車發布時間：2022-06-02 來源：http://www.akware.net/ 瀏覽量：0

混凝土攪拌機簡稱攪拌車，是用來運送建筑用混凝土的專用車輛，在混凝土的運輸過程中，攪拌機的攪拌罐會一直保持勻速轉動，這樣既可以讓混凝土攪拌的更加均勻，又可以防止混凝土凝固。攪拌車行駛的動力來自發動機，發動機帶動驅動裝置讓攪拌車行駛起來，所以說攪拌機的驅動裝置也是非常重要的。

The concrete mixer, abbreviated as mixer truck, is a special vehicle used to transport concrete for construction. During the transportation of concrete, the mixing tank of the mixer will always rotate at a constant speed, which can not only make the concrete mix more evenly, but also prevent the concrete from setting. The driving power of the mixer truck comes from the engine, which drives the driving device to drive the mixer truck, so the driving device of the mixer is also very important.

攪拌車的驅動裝置也是需要保養的，它的保養需要做到以下幾點：

The driving device of the mixer truck also needs maintenance, and its maintenance needs to do the following:

萬向轉動部分是故障多發部位，要按時加注潤滑脂，并要經常檢查磨損情況，及時修理更換，攪拌機的車隊一般都有備用的萬向軸，以保證一旦發生故障就能在幾十分鐘內恢復工作。

The universal joint rotating part is a fault prone part. It is necessary to fill the lubricating grease on time, regularly check the wear condition, and repair and replace it in time. Generally, the mixer fleet has a spare universal joint shaft, so as to ensure that the work can be restored within dozens of minutes in case of a fault.

2. 保證液壓油的清潔，混凝土攪拌車的作業環境一般都比較差，因此一定要防止污水泥沙進入液壓系統。液壓油要按照使用手冊要求定期的進行更換，平時如果發現液壓油中混入水或者泥沙，一定要立即停機清洗液壓系統、更換液壓油。

2. ensure that the hydraulic oil is clean. Generally, the working environment of the concrete mixer is poor. Therefore, it is necessary to prevent the dirty cement sand from entering the hydraulic system. The hydraulic oil shall be replaced regularly according to the requirements of the manual. If water or sediment is found in the hydraulic oil at ordinary times, it must be shut down immediately to clean the hydraulic system and replace the hydraulic oil.

3. 要保證液壓油冷卻裝置有效，要定時清理液壓油散熱器，避免散熱器被水泥堵塞，檢查散熱器電動風扇運轉是否正常，防止液壓油溫度超標。液壓部分只要保證液壓油清潔，一般故障不會多，不同的液壓系統的使用壽命也不相同。

3. ensure that the hydraulic oil cooling device is effective, clean the hydraulic oil radiator regularly to avoid the radiator being blocked by cement, and check whether the electric fan of the radiator operates normally to prevent the hydraulic oil temperature from exceeding the standard. As long as the hydraulic part keeps the hydraulic oil clean, there will not be many common faults, and the service life of different hydraulic systems will be different.

本文的精彩內容由自動混凝土攪拌機提供知識提供，本網站還有很多的精彩內容，更多的內容您可以點擊進入http://www.akware.net我們有專門的客服為您解答問題

The wonderful content of this article is provided by the knowledge of automatic concrete mixer. There are many wonderful content on this website. You can click to enter more content http://www.akware.net We have special customer service to answer your questions

上一頁：下一頁：造成自動上料水泥攪拌車的拌筒不能轉動的原因和措施

熱門產品 / HOT PRODUCT