自拌混凝土攪拌車怎么自身散熱？_公司新聞_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

如何自上料攪拌車零配件的噪音問題？

2021-03-31

自動混凝土攪拌車氣剎和油剎的區別？

2021-05-24

自動攪拌車剎車異常怎么判斷？

2021-04-23

混凝土攪拌機油箱氣孔起到什么作用？

2020-08-17

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自拌混凝土攪拌車怎么自身散熱？

所屬分類：公司新聞發布時間：2020-09-07 來源：http://www.akware.net/ 瀏覽量：0

在高溫季節，也是車輛事故頻發的季節，比如爆胎、自燃、發動機過熱等等，對于自拌混凝土攪拌車來說，比較容易出現散熱器故障，如果攪拌車在行駛過程中散熱器出現故障，自己又不會處理，是讓人著急的，所以駕駛攪拌車的朋友要學會些快速攪拌車散熱器故障的處理辦法。當你的自拌混凝土攪拌車散熱器出現故障，檢查以下幾個部位，基本上就可以問題了。

In the high temperature season, it is also the season of frequent vehicle accidents, such as tire burst, spontaneous combustion, engine overheating, etc., for the self mixing concrete mixer, it is relatively easy to have radiator failure. If the radiator failure occurs during the driving process of the mixer truck, you will not be able to deal with it, which is the most worrying. Therefore, the friends driving the mixer should learn to quickly solve the problem of mixing truck dispersion How to deal with the failure of heat exchanger. When your self mixing concrete mixer radiator failure, check the following parts, basically can solve the problem.

1. 檢查保險開關：自拌混凝土攪拌車是通過液壓傳動系統來驅動罐體的，液壓油散熱系統中容易出現故障的就是保險開關，因此在故障發生后，時間檢查保險開關。

1. Check the safety switch: the self mixing concrete mixer drives the tank through the hydraulic transmission system. The safety switch is the most prone to failure in the hydraulic oil cooling system. Therefore, it is best to check the safety switch as soon as possible after the fault occurs.

2. 檢查驅動風扇：電機是整個散熱系統中為關鍵的部件，散熱效果的好與壞，和電機的轉速及運行的平穩狀態有著直接的關系，它由連接車輛電瓶的電控盒直接供電，用電力驅動電機高速運轉，來帶走熱交換器當中的額熱量，給液壓油降溫。

2. Check the driving fan: the motor is the most important part in the whole heat dissipation system. The good or bad heat dissipation effect is directly related to the motor speed and stable operation. It is directly powered by the electric control box connected to the vehicle battery, and the motor is driven by electric power to run at high speed to take away the heat from the heat exchanger and cool the hydraulic oil.
全自動攪拌車

3. 檢查熱交換器：自拌混凝土攪拌車利用液壓油散熱器來進行降溫。熱交換器上裝有電機驅動風扇進行散熱，讓液壓油正常工作，上面的機械式指針通過檢測管路當中的負壓，如果出現讀數證明液壓油濾清器可能出現堵塞，剛開始出現的時候只需要拔掉上面的橡膠指針歸零，如果后面還出現讀書且拔掉橡膠塞之后還不了的話，就需要更換液壓油濾芯了。

3. Check the heat exchanger: the self mixing concrete mixer uses hydraulic oil radiator to cool down. The heat exchanger is equipped with a motor driven fan to dissipate heat, so that the hydraulic oil can work normally. The mechanical pointer on the heat exchanger can detect the negative pressure in the pipeline. If the reading indicates that the hydraulic oil filter may be blocked, it is only necessary to pull out the rubber pointer at the beginning and return to zero. If there is reading behind and the rubber plug can not be solved after pulling out the rubber plug, The hydraulic oil filter element needs to be replaced.

4. 檢查熱傳感器：溫度傳感器位于熱交換器的進油管上，它的作用就是檢測液壓油的溫度，攪拌車散熱系統發生故障后，如果確認不是保險的問題，那就檢查溫度傳感器。

4. Check the heat sensor: the temperature sensor is located on the oil inlet pipe of the heat exchanger, and its function is to detect the temperature of the hydraulic oil. After the cooling system of the mixer truck fails, if it is confirmed that it is not a safety problem, then check the temperature sensor.

5. 檢查散熱器控制盒：散熱控制盒監控和接受溫度傳感其傳遞過來的信號，當溫度數據超過設定值后，自動接通散熱風扇的電路，讓空氣流通降低液壓油的溫度，因此散熱控制盒損壞后，散熱系統就不能正常工作，需要及時更換，一般情況下，散熱器控制盒不容易損壞。

Five Check the radiator control box: the heat dissipation control box monitors and receives the signal from the temperature sensor. When the temperature data exceeds the set value, it automatically turns on the circuit of the cooling fan to let the air circulate and reduce the temperature of the hydraulic oil. Therefore, after the heat dissipation control box is damaged, the cooling system can not work normally and needs to be replaced in time. In general, the radiator control box is not easy to be damaged Bad.

夏季要注意自拌混凝土攪拌車的散熱系統，車輛一旦出現故障，耽誤卸料，混凝土很可能會在罐體內部凝固，那就麻煩了。

In summer, attention should be paid to the heat dissipation system of the self mixing concrete mixer. Once the vehicle fails, the unloading is delayed, and the concrete is likely to solidify inside the tank, which is troublesome.

今天小編給大家介紹的是關于全自動攪拌車的相關知識，更多的精彩內容請點擊我們的網站咨詢：http://www.akware.net我們后續會有更多的知識為您奉上。

Today, I'd like to introduce to you the relevant knowledge about the fully automatic mixer. For more wonderful contents, please click our website: http://www.akware.net We will have more knowledge for you.

上一頁：正確操作混凝土攪拌車這些情況要熟知！下一頁：水泥攪拌罐車在工作中注意的事項點有哪些？

熱門產品 / HOT PRODUCT