小型混凝土攪拌車保養應該從哪些方面下手？_公司新聞_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

自動上料攪拌車開機前需要做哪些準備工作？

2021-07-12

混凝土攪拌車在維修中需要注意事項

2022-10-07

小型混凝土攪拌罐怎樣做保溫？

2022-11-24

自動上料混凝土攪拌車結構特有哪些？

2022-08-30

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

小型混凝土攪拌車保養應該從哪些方面下手？

所屬分類：公司新聞發布時間：2020-07-18 來源：http://www.akware.net/ 瀏覽量：0

1.小型混凝土攪拌車輪胎的保養：

1. Maintenance of small concrete mixer tire:

混凝土攪拌車輪胎的保養是關鍵的。高速行駛時，如果輪胎爆裂會出大事故，小則傾側、甩頭，大則翻車。所以，每次出車前檢查一下輪胎的狀況很必要。要檢查輪胎的氣壓。氣壓過高、過低都不好，要根據情況做適當的調整。其次，需要檢查輪胎是否有傷痕，比如可能存在的輪胎龜裂、啃胎和輪轂筋條裂紋等都要仔細檢查，做必要的更換。

The maintenance of concrete mixer tire is the key. When driving at high speed, if the tire burst, there will be a big accident. If the tire is small, it will roll over. Therefore, it is necessary to check the condition of the tires before driving. First, check the air pressure of the tire. If the air pressure is too high or too low, appropriate adjustment should be made according to the situation. Secondly, it is necessary to check whether there are any scars on the tires, such as the possible tire cracks, gnawing tires and wheel hub rib cracks, etc., and make necessary replacement.

2.混凝土攪拌車剎車系統的保養：

2. Maintenance of brake system of concrete mixer:

攪拌車剎車系統對于汽車行駛的性關重要。小型混凝土攪拌運輸車的剎車系統主要采用剎車油傳遞剎車力，而重型貨車則采用氣動剎車系統，兩者應采用不同的保養的方法。對于油路制動的汽車，出車前要檢查剎車油的液面。如發現油面下降，要立即檢查剎車油路是否有泄漏的地方。此外還要經常檢查打氣泵的工作情況及氣泵皮帶的磨損，及時更換。
中科攪拌機

The brake system of mixer is very important for the safety of vehicle. The brake system of small concrete mixer truck mainly uses brake oil to transmit braking force, while heavy truck adopts pneumatic brake system. Different maintenance methods should be adopted for both. For oil brake vehicles, check the level of brake oil before driving. If the oil level drops, immediately check the brake oil circuit for leakage. In addition, often check the working condition of the air pump and the wear of the air pump belt, and replace it in time.

3.攪拌車雨刮片的保養：

3. Maintenance of wiper blade of mixer truck:

小型混凝土攪拌車經歷了一夏的辛勤工作后，雨刮片等橡膠制品的老化都已非常嚴重，為確保行車，雨刮片每年更換一次。司機在更換雨刮片時，不要盲目加大刮條的長度、寬度，因為原廠都已對洗刷視野做出了設計，私自加長雨刮片長度雖然可以增加車窗視野的可見范圍，但相對地也會加大雨刮器電機等電器設備的負擔。

Small concrete mixer after a summer of hard work, wiper blade and other rubber products have been very serious aging, in order to ensure driving safety, it is best to replace the wiper blade once a year. When replacing the wiper blade, the driver should not blindly increase the length and width of the wiper blade, because the original factory has made the best design for the cleaning field of vision. Although lengthening the length of the wiper blade privately can increase the visible range of the window field of vision, it will also increase the burden of the heavy rain wiper motor and other electrical equipment.

4.小型攪拌車車燈的保養：

4. Maintenance of small mixer lamp:

小型攪拌車車燈的正常使用是司機行車的重要保障，車主應該特別注意車燈的檢查和保養。在平時的使用和保養中，要注意勤檢查側轉向燈、霧燈、制動燈等工作是否正常，如有發現燈泡變黑應及時更換。水霧的簡單處理辦法就是把大燈打開，利用燈光熱量使水霧消失。

The normal use of the light of small mixer is an important guarantee for the driver's driving safety. The owner should pay special attention to the inspection and maintenance of the light. In normal use and maintenance, it is necessary to check whether the side steering lamp, fog lamp and brake lamp are working normally. If the bulb turns black, it should be replaced in time. The simple way to deal with water mist is to turn on the headlight and use the heat of the light to make the water mist disappear.

上一頁：中科聚峰：混凝土攪拌車選擇要注意什么？下一頁：全自動上料攪拌一體車的結構有哪些?

熱門產品 / HOT PRODUCT