自動攪拌一體車的日常維護事項有哪些？_公司新聞_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

駕駛自上料混凝土攪拌車要避免的問題！

2021-03-22

混凝土設備投資前需掌握的情況

2021-10-22

小型混凝土攪拌車保養應該從哪些方面下手？

2020-07-18

混凝土攪拌設備在修建工程中的重要作用

2021-11-04

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自動攪拌一體車的日常維護事項有哪些？

所屬分類：公司新聞發布時間：2022-01-05 來源：http://www.akware.net/ 瀏覽量：0

混凝土攪拌車了商品混凝土從制備地點到澆注現場的運輸問題,由于混凝土攪拌車的大局限利用,很多用戶對一些日常的利用和維護了解不多,混凝土攪拌車的工作環境又比較惡劣,再加上用戶不注意日常保養,就造成了一些不必要的故障和經濟損失,希望通過小編下面的混凝土攪拌車罐體的維護介紹對廣大混凝土攪拌車用戶的日常使用和維護起到一些作用。

The concrete mixer solves the transportation problem of commercial concrete from the preparation site to the pouring site. Due to the limited utilization of concrete mixer, many users do not know much about some daily utilization and maintenance, and the working environment of concrete mixer is relatively poor. In addition, users do not pay attention to daily maintenance, resulting in some unnecessary faults and economic losses, It is hoped that the following introduction to the maintenance of concrete mixer tank will play a role in the daily use and maintenance of the majority of concrete mixer users.

一、作為混凝土攪拌車,應該保養混凝土攪拌罐,新混凝土攪拌車利用應實時緊固罐體支座與汽車底盤架毗連。每次運完混凝土后及進清洗罐,要知道混凝土是容易和鋼鐵粘結在一起的。

1、 As a concrete mixer truck, the concrete mixing tank should be maintained first. The tank support of the new concrete mixer truck should be fastened in real time to connect with the vehicle chassis frame. Each time after transporting the concrete and entering the cleaning tank, you should know that the concrete is easy to bond with steel.

二、出料的勻稱性問題是混凝土攪拌車機能的一個重要指標之一,它直接影響著施工質量。在運送混凝土時,攪拌筒轉速應節制在2~5r/min,在運送間隔較長可能混凝土的塌落度較大時,出料前應先將攪拌筒快速動彈5~10圈,使內里的混凝土能充實攪拌,這樣出料的勻稱性就會大大提高。若途中混凝失水,到工地應加水調解,并充實攪拌,雖然這種環境應只管制止,但是這樣會使混凝土的質量得不到擔保。有的用戶在利用時不留意節制在運輸歷程中的轉速,過快會讓燃油耗損的更快,過小則會造成混凝土離析。因此應嚴格憑據要求來節制攪拌筒的轉速,以提高混凝土運送質量。

2、 The uniformity of discharge is one of the important indexes of concrete mixer, which directly affects the construction quality. When transporting concrete, the rotating speed of the mixing drum shall be controlled at 2 ~ 5R / min. when the transportation interval is long and the slump of the concrete may be large, the mixing drum shall be quickly moved for 5 ~ 10 circles before discharging, so that the concrete in it can be fully mixed, so that the uniformity of discharging will be greatly improved. If there is water loss in the process of coagulation, add water to the construction site for mediation and enrich the mixing. Although this environment should be stopped, it will not guarantee the quality of concrete. Some users do not pay attention to controlling the speed during transportation. Too fast will make the fuel consumption faster, and too small will cause concrete segregation. Therefore, the rotating speed of the mixing drum should be controlled strictly according to the requirements, so as to improve the quality of concrete transportation.

三、凝土限量不能高出罐體的方量,因為混凝土強度品級差別它的密度也差別,高強度混凝土一般密度也大,同樣的體積,裝多了對車倒霉。輸送混凝土的容量、質量及坍落度應切合車輛利用說明書中的規定,實時加注潤滑油。

3、 The limit of concrete cannot be higher than the square quantity of the tank, because the concrete strength grade is different, and its density is also different. The general density of high-strength concrete is also large, and the same volume is too much, which is bad for the car. The capacity, quality and slump of transported concrete shall comply with the provisions in the vehicle utilization manual, and lubricating oil shall be filled in real time.

四、露天停放過的混凝土攪拌車,裝料前應先將攪拌筒以出料偏向旋轉,把水泥罐內的積水放掉,確保運送混凝土的質量。

4、 For the concrete mixer parked in the open air, before loading, the mixing drum shall be rotated in the direction of discharging, and the ponding in the cement tank shall be discharged to ensure the quality of concrete transported.

五、公路上行駛時,卸料溜槽降處并轉與車身垂直部位,用鎖緊裝置把卸料溜槽鎖緊在機架上,防備由于不牢靠而搖動,造成傷人變亂和影響其它車輛運行。假如階梯狀況欠好,會對罐車的罐軸有損傷。

5、 When driving on the highway, the discharge chute shall be lowered to the position and turned to the position perpendicular to the vehicle body, and the discharge chute shall be locked on the frame with a locking device to prevent injury and disorder caused by unstable shaking and affecting the operation of other vehicles. If the ladder condition is not good, the tank shaft of the tank car will be damaged.

六、卸料前,假如發現水分蒸發、坍落度偏低等不能滿。用戶要求時,可適當向攪拌筒內加水,然后按進料偏向以6~10 r/min速度旋轉30轉后再卸料。

6、 Before unloading, if water evaporation and low slump are found, it can not be full. When required by the user, add water to the mixing drum appropriately, and then rotate it for 30 revolutions at the speed of 6 ~ 10 R / min according to the feed deviation before unloading.

七、混凝土攪拌車在運送混凝土的歷程中攪拌筒不得遏制動彈,以免混凝土發生離析現象。

7、 The mixing drum of the concrete mixer shall not be restrained from moving during the transportation of concrete, so as to avoid concrete segregation.

本文由自動混凝土攪拌車為您提供，我們的網站是：http://www.akware.net我們將以全心全意的熱為您提供服務，歡迎您的訪問

This article is provided by the automatic mixer. Our website is:http://www.akware.net We will serve you wholeheartedly. Welcome to visit

上一頁：選購攪拌車認準這四點下一頁：混凝土攪拌機女殘渣的處理辦法以及未來的發展趨勢

熱門產品 / HOT PRODUCT