自上料攪拌車篩網葉片出現故障需及時維修_行業資訊_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

如何輕松檢查自動混凝土攪拌機磨損情況？

2021-04-21

攪拌車配備“自吸式”水泵

2021-09-10

水泥攪拌罐車工作所注意的八大事項

2020-05-12

水泥攪拌車的用車養車要注意哪些情況？

2020-09-10

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自上料攪拌車篩網葉片出現故障需及時維修

所屬分類：行業資訊發布時間：2022-05-16 來源：http://www.akware.net/ 瀏覽量：0

由于篩網采用普通鋼材，經常存在質量差、耐磨性差的問題，包角不夠合理，因此在應用過程中容易損壞，出現大面積滲漏，甚混音器也無法使用。

Because the screen is made of ordinary steel, there are often problems of poor quality and poor wear resistance, and the wrap angle is not reasonable enough. Therefore, it is easy to be damaged in the application process, large-area leakage occurs, and even the mixer can not be used.

另外，有些攪拌篩的目數不夠科學，篩分率太低，導致已篩分的砂石粒度小。如果自上料攪拌車的篩網尺寸不夠合理，鋼材質量不達標，那么再的自上料攪拌車也無法攪拌出高質量的混凝土。

In addition, the mesh number of some mixing screens is not scientific enough, and the screening rate is too low, resulting in small particle size of screened sand and stone. If the screen size of the self loading mixer is not reasonable enough and the steel quality does not meet the standard, the most advanced self loading mixer can not mix high-quality concrete.

自上料攪拌車篩網故障維修中應使用耐磨鋼絲，設置科學的鋼絲直徑和篩網目數，適當增加篩網的面積，提高篩分率，節約原料，從而提高生產效率。發現篩線斷線后，立即擰緊篩網螺栓，重新設置篩網長度。

Wear resistant steel wire should be used in the maintenance of screen fault of self loading mixer truck, set scientific steel wire diameter and screen mesh, appropriately increase the screen area, improve the screening rate and save raw materials, so as to improve the production efficiency. When the screen wire is broken, immediately tighten the screen bolt and reset the screen length.

自上料攪拌車篩網葉片出現故障需及時維修

If the screen blade of the self loading mixer fails, it shall be repaired in time

此外，葉片故障也是一個重大故障。葉片作為自上料攪拌車設備的重要部件之一，對攪拌過程有著直接的影響，葉片的好壞在一定程度上可以決定自上料攪拌車的使用壽命。因此，在自上料攪拌車使用過程中，葉片的損壞程度往往比較高，因此需要注意葉片技術。

In addition, blade failure is also a major failure. As one of the important components of the self loading mixer, the blade has a direct impact on the mixing process. The quality of the blade can determine the service life of the self loading mixer to a certain extent. Therefore, in the process of using the self loading mixer, the damage degree of the blade is often high, so we need to pay attention to the blade technology.

自上料攪拌車每次攪拌完畢后，需要立即清洗自上料攪拌車的葉片，以便及時清理掉葉片上的污垢。自上料攪拌車的葉片和振動軸承應滴上潤滑油，自上料攪拌車的葉片應防銹除銹。

After each mixing of the self loading mixer truck, the blades of the self loading mixer truck need to be cleaned immediately to remove the dirt on the blades in time. The blades and vibration bearings of the self loading mixer shall be dripping with lubricating oil, and the blades of the self loading mixer shall be rust proof and derusted.

自上料攪拌車廠家認為，定期檢查自上料攪拌車的葉片手柄和葉片焊接質量，檢查葉片磨損和消耗情況。一旦發現異常問題，應及時記錄并更換，并檢查刀片底部導通狀態，避免刀片損壞。泄漏發生在焊點處。

The manufacturer of self loading mixer truck believes that the welding quality of blade handle and blade of self loading mixer truck shall be inspected regularly, and the blade wear and consumption shall be inspected. Once any abnormal problem is found, it shall be recorded and replaced in time, and the conduction state at the bottom of the blade shall be checked to avoid blade damage. Leakage occurs at the solder joint.

本文的精彩內容由全自動攪拌車提供知識提供，本網站還有很多的精彩內容，更多的內容您可以點擊進入：http://www.akware.net我們有專門的客服為您解答問題

The wonderful content of this article is provided by the knowledge of automatic mixer truck. There are many wonderful contents on this website. You can click to enter more contents: http://www.akware.net We have special customer service to answer your questions

上一頁：攪拌機具有很好的實用性下一頁：混凝土運輸攪拌車尾部防漏斗

熱門產品 / HOT PRODUCT