小型自動混凝土攪拌機故障緊急維修應該怎么做？_行業資訊_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

自動攪拌車剎車異常怎么判斷？

2021-04-23

小型自動混凝土攪拌機故障緊急維修應該怎么做？

2021-06-02

小型混凝土攪拌車保養應該從哪些方面下手？

2020-07-18

如何使用自動混凝土攪拌機節省燃油？

2021-07-05

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

小型自動混凝土攪拌機故障緊急維修應該怎么做？

所屬分類：行業資訊發布時間：2021-06-02 來源：http://www.akware.net/ 瀏覽量：0

當小型混凝土攪拌機發生故障時，如果此時攪拌罐里邊面裝有混凝土，那么一時間我們應該盡快想辦法將攪拌罐里邊的混凝土清空，這樣能夠防止水泥凝固在攪拌罐內。

When the small concrete mixer fails, if there is concrete in the mixing tank, we should try to empty the concrete in the mixing tank as soon as possible, so as to prevent the cement from setting in the mixing tank.

這時候會有人問，當發生故障時不是應該先去查看維修混凝土攪拌機的發動機呢？因為如果一時間去維修發動機而導致攪拌罐里邊的混凝土凝固的話，起碼要損失一罐的混凝土是必不可少的，嚴重的情況下可能導致攪拌罐就報廢了損失就更大了，因此我們應該優先慮的是如何盡快的把拌筒內的混凝土排出，其次才是如何維修發動機。

At this time, some people will ask, when there is a fault, shouldn't we check and repair the engine of the concrete mixer first? Because if the concrete in the mixing tank solidifies due to the maintenance of the engine at one time, it is essential to lose at least one tank of concrete. In serious cases, the mixing tank may be scrapped and the loss will be even greater. Therefore, we should give priority to how to drain the concrete in the mixing tank as soon as possible, and then how to repair the engine.

我們來分析下造成混凝土攪拌機的攪拌罐不能轉動有以下三種情況，分別是液壓泵發生故障、液壓馬達發生故障、發動機故障，下邊我們來詳細講解這三種種情況下的應急維修處理方式。

First of all, let's analyze the following three situations that cause the mixing tank of concrete mixer not to rotate. They are hydraulic pump failure, hydraulic motor failure and engine failure. Next, let's explain in detail the emergency maintenance methods under these three situations.

一：液壓泵發生故障

1： Hydraulic pump failure

打開攪拌車攪拌筒檢修孔蓋，旋松馬達上高壓軟管的管接頭，旋轉拌筒使拌筒檢修孔斜向下，將混凝土從攪拌筒檢修孔排出；

Firstly, open the manhole cover of the mixing drum of the mixer truck, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing drum to make the manhole of the mixing drum slant downward, and discharge the concrete from the manhole of the mixing drum;
自動混凝土攪拌機廠家

二：液壓馬達發生故障

2： Hydraulic motor failure

可把救援車的馬達卸下裝在故障車上，再將各個油管接好，啟動救援車即可將拌筒內的混凝土排出。以上談的只是攪拌車使用中應注意的幾個方面，在使用攪拌車的時候要嚴格按照攪拌車廠家的使用說明書操作，定期對液壓系統，底盤等進行保養，才能保證混凝土攪拌機正常的工作和出勤率，發揮其經濟效益。

The motor of the rescue vehicle can be unloaded and installed on the fault vehicle, and then each oil pipe can be connected, and the concrete in the mixing drum can be discharged by starting the rescue vehicle. The above discussion is just a few aspects that should be paid attention to in the use of the mixer. When using the mixer, we should strictly follow the operation manual of the mixer manufacturer, and regularly maintain the hydraulic system and chassis, so as to ensure the normal work and attendance rate of the concrete mixer, and give play to its economic benefits.

三：發動機故障

3： Engine failure

將故障車的高壓膠管從馬達上卸下，把救援用的高壓膠管接上，另一端接在救援車的油泵上，并將應急用的回油管一端接在故障車的馬達泄油口，回油管另一端接在救援車的油泵回油口，利用救援車來控制故障車拌筒的旋轉，將混凝土排出。

Remove the high-pressure hose from the motor, connect the high-pressure hose for rescue, connect the other end to the oil pump of the rescue vehicle, connect one end of the emergency oil return pipe to the motor oil drain port of the fault vehicle, and connect the other end of the oil return pipe to the oil return port of the oil pump of the rescue vehicle. Use the rescue vehicle to control the rotation of the mixing cylinder of the fault vehicle and discharge the concrete.

我們經過現場的測試發現，在生產廠所有工具齊全的情況下，采用第三種方法大約需要1小時，如在工地上時間可能會更長，因此建議采用一和二方法排出混凝土。

After field test, we found that it takes about 1 hour to use the third method when all the tools in the production plant are complete, and it may take longer on the construction site. Therefore, it is recommended to use the first and second methods to discharge the concrete.

感謝您的閱讀，希望以上內容對您有所幫助，如您想了解更多精彩內容請點擊我們的官網：自動混凝土攪拌機http://www.akware.net。

Thank you for reading, hope the above content is helpful to you, if you want to know more wonderful content, please click our official website: automatic concrete mixer http://www.akware.net .

上一頁：自動攪拌車的變速器油面和油質如何檢測? 下一頁：混凝土攪拌機如何達到和？

熱門產品 / HOT PRODUCT