混凝土攪拌罐車工作所注意的八大事項_常見問題_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

常見問題

熱點

全自動混凝土攪拌車在一些城市建設上的特點

2020-10-26

自動上料攪拌車日常維護要4步！

2021-03-19

全自動攪拌車如何防止發生變質及銹蝕？

2021-04-25

保護混凝土攪拌車車漆的方法！

2021-03-26

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

混凝土攪拌罐車工作所注意的八大事項

所屬分類：常見問題發布時間：2022-11-29 來源：http://www.akware.net/ 瀏覽量：0

1、混凝土攪拌車輸送混凝土的容量，質量及塌落度應契合混凝土行業標準和要求。

1. The capacity, quality and slump of concrete transported by concrete mixer truck shall conform to the standards and requirements of concrete industry.

2、大型拌和罐車在混凝土運送過程中罐體制止停轉，避免形成混凝土的凝聚，停轉重啟時會形成對液壓體系、減速機的沖擊，導致液壓泵和馬達的損壞。

2. During the concrete transportation process of large mixing tank truck, the tank body shall be stopped to avoid the formation of concrete condensation. When the tank truck is stopped and restarted, the impact on the hydraulic system and reducer will be formed, causing damage to the hydraulic pump and motor.

3、小型攪拌車在公路上行進時，加長溜槽有必要放置在卸料溜槽支架上并用掛鉤掛牢，不允許掛在主排料溜槽上工作；主排料溜槽要旋轉到固定位置，拉下定位手柄，用鎖緊手柄將彈簧變幅組織鎖止，避免由于不固定而搖晃，形成傷人事端和影響其它車輛工作可能。

3. When the small mixer truck is traveling on the highway, it is necessary to place the extended chute on the discharge chute bracket and hang it firmly with hooks. It is not allowed to hang it on the main discharge chute for work; The main discharge chute shall be rotated to a fixed position, the positioning handle shall be pulled down, and the spring luffing organization shall be locked with the locking handle to avoid shaking due to non fixation, which may cause personal injury and affect the work of other vehicles.

4、作業設備接連工作時刻不該超越8h。

4. The continuous working time of operating equipment shall not exceed 8h.

5、卸料時，如發現水分蒸騰，塌落度偏低不能滿意用戶要求時，可適當向筒內加水，然后以10—14r/min的速度旋轉30轉后卸料，使混凝土充沛拌和。

5. During unloading, if water transpiration is found and the slump is too low to meet the user's requirements, water can be properly added into the cylinder, and then the cylinder can be rotated at a speed of 10-14r/min for 30 revolutions before unloading to fully mix the concrete.

6、攪拌車在空載工作過程中，拌和筒不得停轉避免波動時形成滾道和托輪部分磕碰，導致托輪和滾道的反常損壞。

6. During the no-load operation of the mixer truck, the mixing drum shall not stop to avoid the roller path and roller path from colliding with each other in case of fluctuation, which may cause abnormal damage to the roller and roller path.

7、水箱的水量要常常加滿，以備急用。水箱加水前，有必要翻開放氣閥把箱內空氣放掉；沖刷時翻開氣閥，沖刷結束或者停用時應將水罐內氣體放掉。冬天停放時，水箱和供水體系里，不得有剩下水，避免凍裂。注意：水箱僅在供水時加壓,不要帶著加壓水箱在公路上行進。

7. The water tank should always be filled up for emergency use. Before the water tank is filled with water, it is necessary to turn over the air valve to drain the air in the tank; Turn over the air valve when flushing, and discharge the air in the water tank after flushing or when it is stopped. When parking in winter, there shall be no water left in the water tank and water supply system to avoid frost cracking. Note: The water tank is pressurized only when supplying water. Do not carry the pressurized water tank on the road.

8、混凝土攪拌罐車在滿載混凝土正轉，如要回轉，有必要操作手柄使正轉停穩后，再操作手柄回轉。禁止正轉過程中操作手柄使其回轉。攪拌車

8. The concrete mixing tank truck is in full load concrete forward rotation. If it needs to rotate, it is necessary to operate the handle to make the forward rotation stop stably, and then operate the handle to rotate. Do not operate the handle to rotate it during forward rotation. Price of mixer truck

本文由自動混凝土攪拌機為您提供，我們的網站是：http://www.akware.net我們將以全心全意的熱情為您提供服務，歡迎您的訪問

This article is provided for you by the automatic concrete mixer. Our website is: http://www.akware.net We will serve you with wholehearted enthusiasm and welcome your visit

上一頁：混凝土攪拌車正確操作流程方法，你對了嗎？下一頁：自上料水泥攪拌機系統及相關特點有哪些？

熱門產品 / HOT PRODUCT