攪拌車散熱系統故障怎么？_常見問題_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

常見問題

熱點

小型混凝土攪拌罐怎樣做保溫？

2022-11-24

自動混凝土攪拌車為什么會變得如此普遍了呢？

2021-08-13

自拌混凝土攪拌車如何防止車體罐體容積變??？

2021-01-26

大型混凝土攪拌機這么用可以延長壽命

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

攪拌車散熱系統故障怎么？

所屬分類：常見問題發布時間：2022-06-02 來源：http://www.akware.net/ 瀏覽量：0

夏季，天氣炎熱，高溫天氣比較多，外出的人變的少了，但是路上的車卻依然很多，在高溫季節，也是車輛事故頻發的季節，比如爆胎、自燃、發動機過熱等等，對于攪拌車來說，比較容易出現散熱器故障，如果攪拌車在行駛過程中散熱器出現故障，自己又不會處理，那才是讓人著急的，所以駕駛攪拌車的朋友一定要學會一些快速攪拌車散熱器故障的處理辦法。

In summer, the weather is hot, there are more high-temperature weather, and fewer people go out. However, there are still a lot of cars on the road. In the high-temperature season, it is also a season of frequent vehicle accidents, such as tire blowout, spontaneous combustion, engine overheating, etc. for the mixer truck, it is easy to have radiator failure. If the mixer truck has radiator failure during driving, it is worrying, Therefore, a friend driving a mixer truck must learn some quick solutions to the radiator failure of the mixer truck.

當你的攪拌車散熱器出現故障，檢查以下幾個部位，基本上就可以問題了。

When your mixer radiator fails, you can basically solve the problem by checking the following parts.

1. 檢查保險開關：攪拌車是通過液壓傳動系統來驅動罐體的，液壓油散熱系統中容易出現故障的就是保險開關，因此在故障發生后，先檢查保險開關。

1. check the safety switch: the mixer truck drives the tank through the hydraulic transmission system. The safety switch is the one prone to failure in the hydraulic oil cooling system. Therefore, check the safety switch first after the failure occurs.

2. 檢查驅動風扇：電機是整個散熱系統中的關鍵的部件，散熱效果的好與壞，和電機的轉速及運行的平穩狀態有著直接的關系，它由連接車輛電瓶的電控盒直接供電，用電力驅動電機高速運轉，來帶走熱交換器當中的額熱量，給液壓油降溫。

2. check the drive fan: the motor is the key component in the whole heat dissipation system. The good or bad heat dissipation effect is directly related to the motor speed and smooth operation. It is directly powered by the electric control box connected to the vehicle battery. The motor is driven by electricity to run at high speed to take away the heat in the heat exchanger and cool the hydraulic oil.

3. 檢查熱交換器：攪拌車利用液壓油散熱器來進行降溫。熱交換器上裝有電機驅動風扇進行散熱，讓液壓油正常工作，上面的機械式指針通過檢測管路當中的負壓，如果出現讀數證明液壓油濾清器可能出現堵塞，剛開始出現的時候只需要拔掉上面的橡膠指針歸零，如果后面還出現讀書且拔掉橡膠塞之后還不了的話，就需要更換液壓油濾芯了。

3. check the heat exchanger: the mixer uses the hydraulic oil radiator to cool down. A motor-driven fan is installed on the heat exchanger to dissipate heat to make the hydraulic oil work normally. The mechanical pointer on the top can detect the negative pressure in the pipeline. If the reading indicates that the hydraulic oil filter may be blocked, it is only necessary to pull out the rubber pointer on the top to zero at the beginning. If the reading still occurs later and the problem cannot be solved after pulling out the rubber plug, the hydraulic oil filter element needs to be replaced.

4. 檢查熱傳感器：溫度傳感器位于熱交換器的進油管上，它的作用就是檢測液壓油的溫度，攪拌車散熱系統發生故障后，如果確認不是保險的問題，那就檢查溫度傳感器。

4. check the heat sensor: the temperature sensor is located on the oil inlet pipe of the heat exchanger. Its function is to detect the temperature of the hydraulic oil. After the heat dissipation system of the mixer truck breaks down, if it is confirmed that it is not the problem of insurance, check the temperature sensor.

5. 檢查散熱器控制盒：散熱控制盒監控和接受溫度傳感其傳遞過來的信號，當溫度數據超過設定值后，自動接通散熱風扇的電路，讓空氣流通降低液壓油的溫度，因此散熱控制盒損壞后，散熱系統就不能正常工作，需要及時更換，一般情況下，散熱器控制盒不容易損壞。

5. check the radiator control box: the radiator control box monitors and receives the signal transmitted by the temperature sensor. When the temperature data exceeds the set value, the circuit of the radiator fan is automatically connected to allow air circulation to reduce the temperature of the hydraulic oil. Therefore, after the radiator control box is damaged, the radiator system cannot work normally and needs to be replaced in time. Generally, the radiator control box is not easy to be damaged.

夏季要注意混凝土攪拌車的散熱系統，車輛一旦出現故障，耽誤卸料，混凝土很可能會在罐體內部凝固，那就麻煩了。

In summer, pay attention to the heat dissipation system of the concrete mixer truck. Once the truck fails and the unloading is delayed, the concrete is likely to solidify inside the tank, which is troublesome.

本文的精彩內容由全自動攪拌車提供知識提供，本網站還有很多的精彩內容，更多的內容您可以點擊進入http://www.akware.net我們有專門的客服為您解答問題

The wonderful content of this article is provided by the knowledge provided by the automatic mixer. There are many wonderful content on this website. You can click to enter more content http://www.akware.net We have special customer service to answer your questions

上一頁：混凝土攪拌車可適用的兩大領域下一頁：混凝土攪拌車尾部防漏斗的作用

熱門產品 / HOT PRODUCT